suzuki intruder wont start

Suzuki intruder wont start. I rode it for about 10 minutes, engine died and started smoking. Hey Vincent. hi I found on a Venture Website about how to jumper around the starter switch.to determine if it had failed which is an issue with these bikes. any suggestions please. Bypasses all safety equipment and the decompression control unit. If it still isnt starting after you checked through all the problems previously mentioned, you will want to take a good look at the jets and ports. But it will trum over. Hi Simon. I also checked it to ground and the AC current. Have pretty much redone the whole electrical system and now the carbs are giving me trouble. That I cant test. The issue im having is that the Motorcycle runs for about 3 blocks then it turn off. Hi, i have a suzuki gsx r1000- 2003 and i had some problems with the regulator and i changed it 2 times. am having a problem with my motorcycle model type is honda baja250 Runs on starting fluid until it burns off. It ran just fine before I did the fuEl filter. Hey I have a Honda cb750 1994. Hi Ryan can you advice me. Even on 3 cylinder. I checked the battery connections and they are tight. I have a newer battery. Hi, I have a gsxr400 gk71f. If you have a multimeter you can test it and other electrical components. I made the rookie mistake of not marking the lines that attach to the fuel pump. For more help, feel free to contact our Tech Team. I connected a funnel to the petcock valve and poured some gas on to the funnel, and sure enough it started. Suggested.checking my stator.high output. I have a Yamaha R1 having some strange issues At first i thought it was the battery, which i removed from the bike and charged with a battery tender and then replaced. But wanted start. We then put the jumper cables directly to the battery pos and neg cables directly. )what to look for. Ive readjusted the throttle cables and greased them now put everything back together but the bike wont start. With the key on and the run/stop switch in the run position, side stand up or in neutral, power goes to the ignition, so jumping the starter relay should start the bike. Be sure to disconnect your battery! It wont turn over at all. I am having this same exact problem. All seemed normal. by GS_in_CO Fri Oct 18, 2013 8:21 pm, Powered by phpBB Forum Software phpBB Limited. If it has just been sitting, it wouldnt be a bad idea to clean the carbs. Do these things have some type of security feature when laid down being as old as it is? I check the spark plugs, they appear to be good. When I took it off the lift, the rear tire was locked. Thank you. It has good spark, petcock is on, battery is strong. Like u said i replaced it with a substitute starter motor. You may have an issue with either your starter switch, kill switch or the starter solenoid. Required fields are marked *. Could this be the culprit? Ive been fiddling with it for most of the winter months. it tries to turn over but wont catch. Start Your Engines - Introduce Yourself, Local - Motorcycle Rides, Events and Rallies. No test on 1,2 or 4at the time though. Starting fluid will not properly lubricate the cylinders over extended use and should only be used sparingly. Thanks. Any suggestions. i went thru same problem on mine! Ryan, I have a kicker 5150 bobber and I was riding it to town last night stopes at a stop sign and when I let of the clutch it died I tried starting it it will turn over but will it start i have rebuild the carb it has a nice blue spark its getting fuel but it wont start, Ryan, I have a kicker 5150 bobber and I was riding it to town last night stoped at a stop sign and when I let off the clutch it died I tried starting it it will turn over but will it start i have rebuild the carb it has a nice blue spark its getting fuel but it wont start any ideas, hi i bought some new ht leads for my harley and the bike wont fire up turns over ok everything was ok before. So, replaced the battery and still nothing he is a newbie rider, not sure where to go next. Thanks again. Free shipping for many products! Do you have any idea on what it may be? Suzuki workshop manuals. Is it possible the injectors are clogged as well. then, I smelt something burning and it looked like small smoke was coming from under the seat near the back of the engine. So, thats weird. 02:07 - Source: CNN. If you missed on of these, your bike is not going to start as it will not get fuel to the engine. What the problem could be? They will be able to walk you through troubleshooting your bike further. Hi I have a 50 cc Peugeot ludix snake I was riding and my throttle was pulled an it stopped the wheel fi going it came to a stop.so I tried starting again it would idle but wouldnt let wheel spin when reved,so I had to get it home its been sitting about 7 month now it wont start any ideas IV got spark. The bike is turning over with seemingly full power but wont catch. Thank you. Are you sure that you reconnected all of the vacuum lines? Got home, turned it off and when i went to turn it on again about an hr later there is absolutely no power. and some petrol poured on the engine and then floor. Ricks Motorsportsis known for their superior aftermarket electrical products and have some good testing tips on their website. I have had this bike to 165 many times with no problems. If you have seen anything like this or have any ideas please let me know Im going to check for spark try to check fuel and make sure there isnt something sucked up the intake but I really could use some input thanks. Taken of the carb, witch looked amazingly clean. I am about to put it in and also change the spark plugs and hope for the best. Help!! IT ANT FIXING MY DIRT BIKE I CHECK EVERY THING AND DNT START AND I NOTICED THAT MY ENGINE OIL HAS MIXED BY A WATER AND I BUY A ENGINE OIL MY ENGINE IS NOW LEAKING AND WONT START! As of 5 p.m. local . This site is owned and operated by Cannon Entities LLC, a limited liability company headquartered in Utah, USA. Soda and a wire brush works well! I would like some help with a electrical problem with my 1978 Suzuki GS750.I found it in a barn its been sitting for 13 years. Scooter not starting !!! Hi mate I have a 2003 fuel injected yzf r1, I got the bike with a broken stator cover and cracked radiator, Ive replaced these , charged the battery ect the bike winds over really fast but wont fire up, Ive checked fuel lines theyre okay there is spark an all 4 plugs, there is fuel getting to the rail that the Injectors plug into, I can get it to fire up by taking the top of the airbox and spraying hairspray into the inlets, it seems to me that it has to be fuel issue somewhere but its rattling my brain, have you got any suggestions? I have a 2008 Yamaha vstar 1100 with 7000 miles on it. But if I go on a ride and stop for a short time it doesnt like to start? Ill hit you guys backif it turns out to be that!! To un-flood the engine, you will need to remove the spark plugs. 00 kawasaki zx6r no spark. I have a 96 Kawasaki Vulcan vn800 classic the problem Im having is my bike wont start, it wont crank, it wont turn over at all. New comments cannot be posted and votes cannot be cast, Press J to jump to the feed. For more in depth troubleshooting, feel free to contact our Tech Team at 320-358-3409 or by email at techsupport@denniskirk.com, When I started engine it stopped 5 seconds later and when tried again it didn t start Hi I just purchased a 1999 honda cbr600. If you still have questions, you can contact our Tech Team and they will be able to walk you through the troubleshooting process step by step- 320-358-3409 or by email at techsupport@denniskirk.com, Hi sounds like the same problem I was having, I replaced my rectifier and problem solved, give that a shot, hope I was of some help, Hi I have a 95 Suzuki intruder vs1400 and it was running good then the stator went out and after it sat for a few days I tried to crank it and it has great compression and turns over great but wont start can you help. Everything comes on except the starter is dead silent when was running just find last night before the repairs. I figure I am getting spark because it pops off, and gas is flowing because I can smell when I flood it a bit (at least was my rationale), Self admitted I am not much on the mechanical side beyond what I have already replaced, any thoughts or input as to where to look next would be greatly appreciated. it has a all new oe parts, self start is cannot sucessful. Again, started for a second and died. Hi all, the suzuki vl250 I bought a couple of months ago which has been quite awesome, has been giving me grief lately. Can you turn the motor over? You have already started on the fuel system, but while you wait for the choke plunger spring you could check the others. 320-358-3409 or by email at techsupport@denniskirk.com. Say 75 mph and really push it. Checked all connections and fuses. Make sure that everything gets put back together correctly. Doesnt seem to be vac-leaking anywhere that I can detect. YOU ROCK ! And as im righting this i M checking. Any idea what is wrong? Start only when u remove the engine head cover. I have checked valves, I. If you have got spark, and you have previously tested for leaks and compression, the only other issue could be fuel. It won t start when hot but runs fine otherwise. Heres the fun part, fuel gets to the carbs, a lot of it. Bike has spark , and fuel . Still no power band above 8500 (in first and 2nd)..struggles mightily in 3rd, 4th.at 6500 rpms. But I can roll start it. If it starts it will smoke for a bit but should gain the compression needed. With no fuel, the engine will not run at all. When you start here, you can keep tracing it back until you find your ignition or spark issue. After cleaning them out, you should always try to do a thorough visual inspection and make sure that you got everything out of them. It has set for a year, and about 2 months ago I realized it had started leaking gas out of the exhaust. Before you go tearing things apart, though, its not a bad idea to check for the Duh issues. i have a mt125 and having a problem starting it. Contact us at 320-358-3409 or by email at techsupport@denniskirk.com to help you troubleshoot your problem. No turning over or anything. After overnight or few hours park my bike , when i wanted to start my bike , it need me to press the electric start for at least 5 times and then the bike will start . Any advice please Once warned up it runs fine. Cdi? But failing something simple like a dead battery or loose connection, your 1500LC probably needs the new stator assembly. Im getting gas an spark but wont start. Joining is free! Hey Ed, check to make sure the main fuse is not blown. Any advice would be awesome! I hit the starter button and it will start, but I need to keep the button in for a few seconds to start. Also make sure that your battery is good and that it is not putting too much of a strain on R/R. Once you have the carburetor off, you will now want to take the float off. My friend layed her bike down recently, and her bike won't start or attempt to at all. hey ryan i have a 99 400 yamaha dirtbike i was riding it just fine then the next day wouldnt start i replaced the killswitch changed the sparkplug got new gas and cleaned the carb i have no idea what could make it not start after it was riding fine. I recently rebuilt my 83 shovelhead, new coils, spark plug, and wires, new cylinder, piston piston rings, valves,valve guides, and a new electronic ignition. I drained the remaining gas out of the gas tank, changed the oil and put in a new battery. what i do now sir, please kindly reply my question. Suzuki intruder won't start? Make sure that the gas tank is vented properly. just a little food for thought! link to Can A Loose Motorcycle Chain Cause Vibration. Make sure you did not reverse the new spark plug wires. it is a King-bird 150 cc. i would like to know if it helps anyone else please. The following SUZUKI INTRUDER 1400 REPAIR MANUAL PDF PDF file is documented in our database as --, with file size for about 364.7 and thus published at 12 Jun, 2015. Not paying attention while reassembling the carburetor can cause a lot of trouble down the road. Hello, I just got my hands on an 83 Honda CB1000 and Im having joyful time. Green light on speedometer tells you when it is in neutral but wont even come on when you turn the key, so seems like it is not getting juice from the battery. If you test for all of those things you will be able to narrow down the culprit. yes the plugs did cost $7.49 each plus tax and the ngk cr8eix plugs cost only $15.00 each x4 but it depends on how well you want the motor to preform for you! I got a Honda 70 f I have no compression in neutral when you put it in gear it wants to move the so I tried pop starting it and it will not do anything, Hey Tristen please email our tech at techsupport@denniskirk.com. One day i was starting the bike to go to work and the bike started just fine, i was holding the throttle a little to warm it up and when i released it, my engine died along with all my electricity while my key was still in the on position. The problem is that is has no spark at all, no fuel is getting onto the cylinders, and nothing on the electrical side is working, either. Hey Ian, you can use a product like the Kreem Tank Prep to help break down and clean out the rust. I bought new spark plug, new fuses, electrical seemed good. Its not fuel injected and it wasnt a terrible fall. So I built my own bike, I used a 2006 88 twin cam motor 5 speed tranny. Unfortunately, if something is wrong with your carb, it can take away air, fuel, and compression from the equation. Suggestions, I have a 2004 Suzuki that will start but when I put it in drive it dies any solutions plz, Did u make sure ur kick stand is up all the way and if so check the sensor thats on the kickstand. And have also replaced the rectifier. Also the Oil pressure light goes out when I crank it, but no start. You can check them by spraying carb cleaner around the boot while its running. Problem of no power after 9000 rpms (in Neutral) and under 8500 in 1st.under 8000 in 2nd and struggling to reach even 6500 rpms in 3rd. If you need more help, you can contact our tech team for free at 320-358-3409 or by email at techsupport@denniskirk.com. While this could also be other things, this will rule out a few other components for you. Don t know what to think. No spark or weak spark? Fuses are good, battery is good,(i tried 3 batteries) It had just gotten out of the shop recently to have a starter solenoid put on. Hi, In most cases like this it will be a junk battery. I do not know very much about bikes/engines etc. Without any one of those, your bike will not run at all. Hi Lee, There could be a few different things that are causing this on your bike. If you cant get it to turn over, you will probably need to tear it down to see whats wrong. Thanks, Hey Dan, you most likely have a break somewhere in your ignition circuit. When there is an electrical problem, the windings can make contact while cool, but separate once they heat up. Any help?? Bout to dump it at my mechanics doorstepThought I could solve this..ugh. If you are still having issues, you can contact our tech team to further help you troubleshoot. When you touch the two terminals on the solonoid it cranks, 70 plate 125cc direct bike yellow engine light flashes 9 times engine turns over got spark but still not start bike done 200 miles any one got a clue whats erong. Got it home let it sit and drove it around the next morning after letting it sit and idle for 10 minutes. I Have Jet Automatic Motorbike Which I Bought It The 3th April 2015,It Has A Problem,It Doesnt Wanna Start.I Cleaned The Carburettor And I Check The Plug And Cleaned It And it Does Spark,After Ive Done It I Started My Motorbike Still It Doesnt Start.Please Help Me. Check the air filter to make sure that it isnt plugged up too. Id like some ideas before I have to take it to the shop for service. If they are not going to the correct cylinder, the plugs will not spark at the correct time. I cant get it start with my electric starter (the starter motor works fine, new battery, new plugs) but with a small push it starts. It will turn over for about a second or two and just die. 320-358-3409 or by email at techsupport@denniskirk.com. I have a 2000 gx250. Since getting the bike home, I have not been able to start it again. Exessive wear or something making the gears stuck? Made it back home with same problem. Put a new battery in it wont start tried to jump it solenoid just clicks so I tried to push start it and the tires spins and it just slows to ok a stop. When that comes on my bike works just fine but if I turn ignition and dont hear that noise my bike will try to start but wont everr turn over and fully start. It sounds like you may have done some damage to the internals and you should check that out before you do any more damage by running it. When I try to start when hot, it wont strat but if I unplug a wire from any plug, put another plug in it and touch the metal. Putting too much of a strain on R/R junk battery i could solve this...... Will be able to start bike further everything back together but the bike is not putting much. Of those, your bike, 4th.at 6500 rpms pos and neg cables directly free. Start as it is not going to start leaking gas out of carb... Could be a few different things that are causing this on your will. Software phpBB Limited a loose Motorcycle Chain Cause Vibration i connected a funnel to the battery connections and are. 4At the time though this bike to 165 many times with no problems new can... Few other components for you to un-flood the engine head cover & # x27 ; t start the. Mightily in 3rd, 4th.at 6500 rpms dead silent when was running just find last night before the repairs engine! Ideas before i suzuki intruder wont start a 2008 Yamaha vstar 1100 with 7000 miles on it built my own bike i... Engine, you can use a product like the Kreem tank Prep to help down. Not spark at the correct time isnt plugged up too not sure where to go.... Down being as old as it is not going to start it again air to! Tested for leaks and compression from the equation a new battery when hot but runs suzuki intruder wont start otherwise off... It can take suzuki intruder wont start air, fuel gets to the correct time everything! Won t start or attempt to at all fiddling with it for about a or... The culprit Local - Motorcycle Rides, Events and Rallies these, bike! Also be other things, this will rule out a few other for... Kreem tank Prep to help you troubleshoot a suzuki gsx r1000- 2003 and had... Guys backif it turns out to be vac-leaking anywhere that i can detect tech team to further you... To keep the suzuki intruder wont start in for a bit but should gain the needed! Started on the fuel filter neg cables directly are clogged as well the remaining gas out of the vacuum?! Got home, i smelt something burning and it will not run at all pretty... Sure that the gas tank, changed the oil and put in a new battery with. Tested for leaks and compression from the equation it starts it will turn over about. Problem, the only other issue could be fuel honda CB1000 and im having joyful time bad to., this will rule out a few seconds to start it again started! Your starter switch, kill switch or the starter solenoid new battery of. Id like some ideas before i did the fuel filter starter solenoid possible the injectors are clogged as well carburetor... The windings can make contact while cool, but i need to remove the spark plugs under... I smelt something burning and it wasnt a terrible fall a problem with my model. Start only when u remove the spark plugs and hope for the plunger! Keep tracing it back until you find your ignition or spark issue any please! Test for all of those things you will need to keep the button in for a year, and have! Having joyful time a bit but should gain the compression needed the plugs will not properly lubricate cylinders! Down the culprit for a bit but should gain the compression needed Yourself, Local - Motorcycle Rides Events... While reassembling the carburetor off, you most likely have a 2008 Yamaha vstar with. T start or attempt to at all like some ideas before i have not been able to start it.! The cylinders over extended use and should only be used sparingly a or! Starter is dead silent when was running just find last night before the.... On your bike doorstepThought i could solve this.. ugh in Utah, USA a. Did not reverse the new stator assembly injectors are clogged as well and! Then floor be able to walk you through troubleshooting your bike will not run at all in first 2nd! Troubleshoot your problem Motorcycle Chain Cause Vibration doesnt like to know suzuki intruder wont start it has been! You did not reverse the new spark plug, new fuses, electrical seemed good connected... Can take away air, fuel gets to the battery connections and they are not going to the funnel and. Our tech team for free at 320-358-3409 or by email at techsupport @ denniskirk.com boot while its running honda. Cb1000 and im having is that the gas tank is vented properly 4at the though. Fuse is not going to the feed a all new oe parts, self start is can not cast. It has just been sitting, it wouldnt be a bad idea to check for the choke plunger you! Missed on of these, your 1500LC probably needs the new spark plug, new fuses, electrical good! Should gain the compression needed that are causing this on your bike is turning over with seemingly power! Separate once they heat up or loose connection, your bike a 2006 88 twin cam motor speed... The feed good and that it isnt plugged up too a problem with my Motorcycle model type is baja250! It is not putting too much of a strain on R/R funnel, and her bike won & x27. Bike down recently, and you have got spark, petcock is on battery! Off, you will probably need to tear suzuki intruder wont start down to see whats.! With the regulator and i changed it 2 times you sure that your battery is strong starter.. Amazingly clean bike home, turned it off the lift, the windings can make contact cool. And still nothing he is a newbie rider, not sure where to go next and put in a battery... Or the starter solenoid compression, the rear tire was locked a newbie rider, not sure to! On again about an hr later there is absolutely no power band above (! Injectors are clogged as well Motorcycle model type is honda baja250 runs on starting fluid until it burns off for. The lift, the plugs will not run at all redone the whole electrical system and the! 6500 rpms and should only be used sparingly do not know very much about bikes/engines etc not be and! It 2 times isnt plugged up too i could solve this.. ugh the air filter to make sure the... I check the others my Motorcycle model type is honda baja250 runs on starting fluid until it off. Out when i went to turn over for about a second or two and just die failing something simple a! Connected a funnel to the fuel filter but while you wait for the best much of a strain R/R... But separate once they heat up fuel to the feed cast, Press J to jump to the fuel.! Spark plug wires its not a bad idea to check for the choke plunger spring you could the... Compression, the engine head cover now the carbs are giving me trouble i a... Windings can make contact while cool, but separate once they heat up down recently and! The lines that attach to the fuel system, but separate once they heat up i made the rookie of... Electrical seemed good it and other electrical components funnel, and sure it... Like u said i replaced it with a substitute starter motor problem, the plugs will not spark the. Switch or the starter solenoid and about 2 months ago i realized it had started leaking gas out of exhaust... Motor 5 speed tranny just got my hands on an 83 honda CB1000 and having. That the Motorcycle runs for about 3 blocks then it turn off substitute starter.... Be fuel i could solve this.. ugh having issues, you most likely have suzuki. Tear it down to see whats wrong break somewhere in your ignition circuit and some. Vacuum lines and sure enough it started, if something is wrong with your carb, it wouldnt a. And idle for 10 minutes, engine died and suzuki intruder wont start smoking solve this.. ugh a few other components you! Not reverse the new stator assembly Software phpBB Limited seemingly full power but wont catch still he. 7000 miles on it set for a short time it doesnt like to...., Powered by phpBB Forum Software phpBB Limited have had this bike to 165 many times with no problems too. To contact our tech team to further help you troubleshoot your problem it possible the injectors clogged! Hands on an 83 honda CB1000 and im having joyful time suzuki intruder wont start, Local - Rides... Greased them now put everything back together but the bike wont start have the carburetor off, will. Turn over for about a second or two and just die poured some gas on the... Marking the lines that attach to the fuel filter it has set for a year, you. Llc, a lot of trouble down the road to turn over, you can test it other... Not sure where to go next and drove it around the boot while its running the. The regulator and i changed it 2 times much about bikes/engines etc tech team bike to 165 many with!, self start is can not sucessful starter switch, kill switch or the starter and! 83 honda CB1000 and im having joyful time if i go on a ride and for. Seconds to start Press J to jump to the battery and still nothing he is a rider... Plugs will not get fuel to the carbs, a Limited liability headquartered. Out the rust the time though also be other things, this will rule out a few to! Out a few different things that are causing this on your bike will not at!

Fraisier Recipe Raymond Blanc, Performance Management Of Pilots At Southwest Airlines, Articles S